Specifications, Service and Repair of Farm and Lawn Tractors

________________________________________________________________________________

John Deere 2032R Troubleshooting

John Deere 2032R Engine Troubleshooting

Engine difficult to start or won't start: Fuel filter element is dirty. Change filter element. Air trapped in fuel system. Bleed air. Fuel injection nozzles are damaged. Replace injection nozzles. Fuel injection pump malfunction. Replace or rebuild injection pump.

Engine shuts off suddenly while running: Improper fuel injection timing. Set up as recommended. Clogged fuel filter. Clean or replace the filter. Low coolant temperature. Warm up the engine.

Engine stalls after starting: Dirty fuel filter. Filter maintenance required. Fuel injection pump malfunction. Install a new fuel pump or repair. Intake air restriction. Carry out maintenance on air filter.

Engine is overheated: Clogged radiator fins or leaking radiator cap. Clean radiator or change cap. Insufficient coolant. Add coolant fluid to cooling system and also check it for leaks. Damaged or worn fan belt. Belt replacement is recommended. Insufficient engine oil. Check and refill engine oil.

Low engine power: Fuel injection nozzles are faulty or clogged. Replace injection nozzles. Fuel lines or hoses are clogged. Clean fuel lines and hoses. Restricted intake air. Clean air cleaner element. Cylinder head gasket is blown. Change cylinder head gasket.

Engine knocks or noises: Engine is cold. Normalize the temperature by warming up the engine. Engine oil level low. Fill up the oil to required level. Fuel injection pump timing is not adjusted. Set up as recommended. Pistons are broken or worn. Install new pistons. Connecting rod is not aligned or defective. Connecting rod needs to be aligned or changed.

Engine stalls when idle: Low idle speed setting is incorrect. Correct low idle adjustment. Valve clearance is out of adjustment. Check and adjust. Fuel injection pump is not operating properly. Install a new pump or rebuild.

Oil pressure is low: Low crankcase oil level. Fill crankcase to proper oil level. Oil pump is damaged. Repair or replace. Oil filter element clogged. Service or replace engine oil filter.

John Deere 2032R Hydrostatic Transmission Troubleshooting

HST transmission is making noise: Speed control linkage is worn or unadjusted. Change or adjust linkage. Transmission is under excessive load. The load should be reduced. Low transmission oil level or contaminated oil. Fill to required level or change the transmission oil. Relief valve is stuck. Change relief valve. Transmission parts are worm or defective. Replace or repair defective components.

Transmission overheats: Excessive transmission load. Load needs to be reduced. Plugged or defective cooling components. Inspect all cooling components and service or change if necessary. Insufficient transmission fluid. Need to add transmission fluid. Dirty transmission oil filter element. Clean or change transmission oil filter.

Power is too low: Low oil level. Add oil to the transmission housing. Stuck relief valve. Install a new valve. Defective or not adjusted speed control pedal linkage. Adjust or change linkage.

Transmission fluid leaks: Clogged transmission fluid return pipe. Clean or change return pipe. Seals or gaskets are broken. Install new components. High internal transmission case pressure. Change defective parts.

John Deere 2032R Hydraulics Troubleshooting

Excessive hydraulic system heat: Hydraulic oil type is improper. Fill up with the proper type of oil. Hydraulic oil is contaminated. Fill up with fresh hydraulic oil. There is air in the hydraulic system. Bleed hydraulic system. Main relief valve is damaged. Relief valve replacement required.

Hydraulic fluid pressure too low: Insufficient hydraulic fluid. Fill up the hydraulic fluid. Hydraulic fluid filter element is clogged. Install a new hydraulic filter element. Leaking hydraulic lines. Find leaks in the system and fix it. Hydraulic control valve block is not set properly. Use the proper setting. Hydraulic pump failure. Install a new hydraulic oil pump. Hydraulic cylinder failure. Install a new hydraulic cylinder or repair it.

3-point hitch can't lift or lifts too slowly: Hydraulic pump failure. Repair or replace hydraulic fluid pump. Faulty main relief valve. Relief valve must be changed. Hydraulic control valve block is defective. Replace or repair the valve. Hydraulic cylinder failure. Repair or install a new hydraulic cylinder. Hydraulic oil is insufficient. Need to add oil. Hydraulic fluid filter element is clogged. Service or replace the hydraulic filter. Hitch is under excessive load. The load should be reduced.

3-point hitch won't lower or lowers slowly: Broken hydraulic cylinder. Repair or install a new hydraulic cylinder. Incorrect adjusted hydraulic control valve. Adjust correctly. Hitch cross shaft is worn. Replace the shaft. Three-point hitch is out of adjustment. The hitch must be adjusted.

Hitch lift or drop is not smoothly: Hydraulic oil contamination. Change the oil. Hydraulic pump is faulty. Replace or repair hydraulic oil pump. Air in the hydraulic system. Air bleeding. Defective hydraulic control valve. Replace or repair the valve. Hydraulic cylinder not working. Repair or change hydraulic cylinder.

John Deere 2032R Steering Troubleshooting

Excessive steering wheel free play: Steering column shaft or coupling has maximum wear. Replace defective part. Steering pump failure. Check the steering pump and replace if necessary. Loose or worn steering linkage components. Replace or repair steering linkage. Power steering control valve has malfunction or wear. Inspect and replace as required.

Steering is stiff: Air in steering hydraulic system. Need to bleed air. Clogged steering filter element. Service steering filter. Steering fluid level is insufficient. Add oil to steering system. Power steering control valve has malfunction or wear. Repair or change the steering control valve. Steering pump stopped working. Steering pump needs to be replaced or repaired. Pump flow control valve is worn or stuck. Install a new flow control valve or clean it. Incorrectly installed or worn steering column. Install the steering column correctly or replace it. Tire pressure uneven. Inflate the tires correctly. Improper toe-in. Check toe-in and correct. Steering cylinder leaks. Change worn piston seals or damaged piston rod.

Tractor pulls to right or left: Power steering control valve is damaged or worn. Repair or replace the steering control valve. Steering cylinder is faulty. Change or repair hydraulic steering cylinder. Not adjusted toe-in. Check and adjust toe-in. Worn or loose steering linkage joints. Change or repair steering linkage. Improperly adjusted or worn front wheel bearings. Change or adjust the bearings properly. Uneven wear on front tyres. Replace the tyres.

John Deere 2032R Electrical System Troubleshooting

Battery will not charge: Loose or corroded wire connections. Service or tighten cable connections. Faulty battery terminal clamps. Terminal clamps should be changed. Battery failing. Battery replacement required. Defective or loose belt. Adjust belt tension or change the belt.

Starter motor cranks slow: Low battery voltage. Low battery charging, charge as required. Battery is not holding charge. Service or replace the battery. Wires are disconnected or battery terminals are corroded. Connect wires correctly or change terminals.

Starter does not work: Battery is low or faulty. Change or recharge battery. Wiring is improperly connected or disconnected. Check wiring and connect properly. Low battery output. Charge the battery. Starter motor is defective. Repair or install a new starter.

________________________________________________________________________________

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS ATTACHMENTS
1023E 2025R 2210 2520 3032E
3046R 3520 4066R 4105 4200
4320 4400 4520 4600 4720
430 420 455 X300 X350
X485 X500 X590 X700 X738

________________________________________________________________________________________

JOHN DEERE FRONT END LOADERS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS MAINTENANCE

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS TROUBLESHOOTING
2640 3040 3310 3650 4100
5050D 5090R 5410 6105R 7200R
E130 L111 LA110 LT155 X300R

________________________________________________________________________________________