Specifications, Service and Repair of Farm and Lawn Tractors

________________________________________________________________________________

John Deere 5093E - Troubleshooting Tips

Recently I recognized a breakdown on my John Deere 5093E with 553 loader. Motor will not crank. Tell me what could be the failure?

You must use the recommended fuel grade. Fuel pump not working. Check and repair. Wrong fuel injection pump timing. Adjustment required.

5093E tractor damages. Engine low on power. How should I solve the problem?

Burnt nozzle Have it repaired by the service representative. Engine’s moving parts seem to be seizing - Repair or replace.

Can someone say me what is fault if engine starts but stops after a short period of time?

Insufficient fuel supply - Top up fuel and air-bleed fuel system. Wrong valve clearance.

John Deere 5093E tractor issue. Transmission shifts hard. What could it be?

Transmission misaligned - Correct alignment.

Somebody help me why steering wheel turns around very easy? What are my actions to get rid of problem?

Minimum Oil Rating - Pour full. Steering cylinder has problems - Replace the defective part. The steering pump is defective - Check the steering pump.

I purchased a JD 5093E in july. Today there is failure. Diesel engine will not start. Could somebody help me diagnose the source of problem?

Starter turns bad - Diagnose starter and reinstall if necessary. Fuel line is clogged up - You should make washing and cleaning. Filter element is dirty - Change it. Piston rings worn out - Install new piston rings.

I have the same tractor. Yesterday I saw the steering is very hard. Can anybody tell me what's malfunction?

Minimum Oil Rating. Power steering oil low. Refill oil to the required level. Steering shaft and sector gear stuck - Replace it. Breakage of hydraulic hoses. Eliminate a defect. Steering pump is defective. Install the new pump. Power steering defect. Diagnose the power steering.

John Deere 5093E tractor issue. Diesel engine hard starting. Help me find prime cause of issue. What needs to be repaired?

Improper engine oil viscosity. Loose electrical connections. Cold start system used incorrectly. Wear or deformation of piston rings. High pressure fuel pump drive shaft is broken. Water in fuel. Fuel too heavy at low temperature.

JD 5093E diesel breakdowns. Motor starts hard sometimes. How can i solve a problem?

Restricted Fuel Lines. Air in fuel system. Exhaust pipe is clogged. Low voltage - Charge battery. Dirty or faulty injectors. Clogged fuel filter. Clean or replace fuel filter. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering doesn’t function on my tractor. What's a breakdown?

The air was formed in hydraulic system. We recommend you remove air. Oil low level in system. Fill the tank. Problem with the hydraulic steering cylinder Check and repair.

I have the same tractor. Why diesel motor doesn't start? How do i fix malfunction?

Wrong valve timing - Make adjustment. Bad cylinder compression. Cylinder bores are worn - Repair it. Leaks between seats and valves - Eliminate leak.

5093E tractor breakdowns. This is the engine knock. what is the probable malfunction?

Lack of oil. You should pour this. Cooling temperature is minimum.

I have a problem why tractor front axle to rattle constantly when driving?

Teeth of gears broke. You need to install new gears. Roller bearings are firmly erased. Replace it.

I have this model less than five years. Often motor start is difficult. How to eliminate?

Injector has clog. Need checking a nozzle. The fuel pump problems. Replace injection pump.

I have the exact same model. Can someone explain to me what's problem if differential lock is defective abruptly? What's solution to the problem?

This is the diaphragm rupture or disks of the friction clutch are worn out. Replace parts.

Our company has John Deere 5093E with 553 loader. Diesel engine does not start. Help me how can I fix this?

Most likely this is a clogged fuel filter. Or high-pressure fuel pump is improperly adjuste.

I have the problem. Engine constantly overheats. What could be the problem?

Little coolant in the cooling system. You need to fill the system. Low oil - Replace the oil to correct grade. Oil level is less - Top up to level. Overloaded - Reduce the load. Running out of engine oil - Add engine oil. Too much load - you must reduce the load or speed. Loose or problem fan belt. Adjust belt tension.

My dad uses JD 5093E with 553 loader. Today he heard knocking in the crankcase of the drive axle. What's wrong?

These signs point to destruction of bearings.

Help with the question what is fault if motor excessive white smoke at idle?

When white smoke appeared from the exhaust pipe you required to change piston rings immediately. Excessive engine oil - Reduce to specified level.

________________________________________________________________________________

________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS SPECIFICATIONS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS ATTACHMENTS
1023E 2025R 2210 2520 3032E
3046R 3520 4066R 4105 4200
4320 4400 4520 4600 4720
430 420 455 X300 X350
X485 X500 X590 X700 X738

________________________________________________________________________________________

JOHN DEERE FRONT END LOADERS

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS MAINTENANCE

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

________________________________________________________________________________________

JOHN DEERE TRACTORS TROUBLESHOOTING
2640 3040 3310 3650 4100
5050D 5090R 5410 6105R 7200R
E130 L111 LA110 LT155 X300R

________________________________________________________________________________________