________________________________________________________________________________

John Deere 5104 - Troubleshooting Tips

Yesterday I discovered some trouble with my John Deere 5104. Diesel motor does not turn over. Explain me what is the damage?

You must use the recommended fuel grade. Fault in fuel injection pump. Check and repair. Incorrect fuel pump timing. Need to set up.

JD 5104 issue. Low engine power. How to correct the situation?

Incorrect valve gap. Incorrect valves clearances. Loose or damaged wiring. Check all wiring. Bleed air from the fuel system.

Can someone say me what is defect if engine stops during operation?

Seized engine due to lack of oil, the wrong oil or lack of coolant.

5104 tractor failure. Transmission shift hard at low speeds. What's fault?

Defective or worn clutch - Change worn parts.

Somebody help me why my steering wheel rotates not resisting? How do I act to fix an issue?

Low hydraulic oil level in the tank - Pour full. This is a steering cylinder malfunction - Repair it. Defect in the power steering pump - Replace pump.

I got a John Deere 5104 in july. Currently there is issue. Motor will not start. Could anyone help me find the cause of damage?

Starter motor turns engine too slowly - Diagnose starter and reinstall if necessary. Clogging in the fuel line - Clean and wash. Filter element is dirty - Change it. Worn piston rings - Must be repaired.

I use the same tractor. Recently I noticed steering wheel turns bad. Help me find out what's issue?

The minimum oil level. Poorly installed steering column - Correct. Faulty steering pump. Leak in hydraulic connections. Eliminate a fault. Pump of power steering is broke. Install the new pump. Power steering is damaged. Install the new power steering.

5104 tractor issue. Diesel engine hard to start. Need help to find the cause of trouble. What should I check?

Fuel tank or fuel filter is clogged by dirt. Head gasket leaking. Cold start system worked incorrectly. Damage or wear of piston rings. Injection pump drive shaft is defective. Water in fuel. Fuel too heavy at low temperature.

John Deere 5104 diesel motor issues. Engine hard to start regularly. How do i resolve an issue?

Restricted Fuel Lines. Air leaks on suction lines. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering not working on my tractor. What's a breakdown?

The hydraulic system has air. You need draw out air. Low oil rate in system. Pour completely. Problem with the hydraulic steering cylinder Check and repair.

Having used the same tractor. Why diesel does not start? How do i resolve the question?

Valve timing is improper - Set a valve timing. High or Low compression. Worn cylinder bores - Repair it. Leaks between seats and valves - Need Removal of leakage.

JD 5104 troubles. I hear the engine knocking. what kind of failure?

This is a small residue of engine oil. Fill up. Too much bearing play. Injection volume incorrectly set - Adjust settings.

I can't find the reason why front axle to make a lot of noise chronically when tractor run?

This is the failure of any gear. Replace gears. ball bearings crumbled. Swap the replacement.

I have this model about four years. Regularly motor start is difficult. What you need to fix?

Injector has clog. You should checking a nozzle. The fuel pump has a malfunction. Install a new high-pressure fuel pump.

I have the same tractor. Tell me why differential lock is defective abruptly? How to solve the problem?

The diaphragm torn or wear of discs friction clutch. Requires repair.

We have John Deere 5104. Motor will not start. Help me what's issue?

Possibly this is a clogged fuel filter. Or injection pump to lost adjustments.

Please help me. Motor overheats regularly. What is the fault?

Low coolant level - Fill coolant and check cooling system for loose connections or leak. Clogged grille, radiator screens - Clean. Clogged radiator - Clean the core. Coolant level low - Add coolant. Cooling fan trouble. Excessive load - Reduce load or speed. Fan belt is damaged. Change as required.

My father has JD 5104. Three days ago he heard a strange noise in the rear axle. What is the malfunction?

All sounds talk about bearing problems.

Please explain me what is fault if diesel exhaust white gas?

When white gas visible from the exhaust pipe you necessary to carry out replacement of piston rings immediately. Cold-running engine - Allow to warm check thermostat.

JOHN DEERE TRACTORS ATTACHMENTS
1023E	2025R	2210	2520	3032E
3046R	3520	4066R	4105	4200
4320	4400	4520	4600	4720
430	420	455	X300	X350
X485	X500	X590	X700	X738

JOHN DEERE TRACTORS TROUBLESHOOTING
2640	3040	3310	3650	4100
5050D	5090R	5410	6105R	7200R
E130	L111	LA110	LT155	X300R