________________________________________________________________________________

John Deere 5510 - Troubleshooting Tips

Recently I discovered some problem on my 5510 tractor. Diesel can not crank over. Tell me what could be the breakdown?

Wrong type or grade of fuel used. Fault in fuel injection pump. Check and overhaul. Wrong fuel injection pump timing. Adjust if needed.

JD 5510 damages. Engine loses power. How to solve the problem?

Too much oil in engine. Uneven fuel injection - Replace injection pump. Valve clearance incorrectly.

Tell me what is defect if diesel engine stops during operation?

Airlock in fuel line. Fuel-line is leaking air - Retighten clamps, replace defective pipes.

John Deere 5510 tractor issue. Transmission shifts hard in reverse. What happened?

Excess amount of lubricant - Drain to level of filler plug.

Please give me information why steering wheel rotates too easy? What should I do to solve the problem?

Low Oil Rating - It is required to add oil. Steering cylinder has a defect - Change the seal. Pump steering broke - Install a new pump.

I acquired a JD 5510 loader in november. Today there is issue. Diesel motor will not start. Could someone help me find the cause of malfunction?

Starter does not work - Replace or repair. Clogging in the fuel line - Wash and clean the fuel line. Dirty fuel filter element - Replace fuel filter. Piston ring failure - Need replacement of piston rings.

I use the same tractor. Recently I noticed steering wheel operate heavy. Somebody tell me what is problem?

Minimum Oil Rating. Insufficient oil delivery from the hydraulic pump. Check the hydraulic pump suction line and filter. Fix as required. hydraulic connection leaking. It is necessary to eliminate a damage. Power steering pump defect. Repair the pump. Power steering defective. Requires repair.

John Deere 5510 tractor failure. Diesel motor is difficult to start. Need help to specify main cause of damage. What should I check?

Loose or damaged wiring. Check all wiring. Weak or dead battery. Cold start system used incorrectly. Defect or failure of piston rings. Valve Leakage/Adjustment Bad. Water mixed in the fuel. Crankcase oil too heavy. Use oil of proper viscosity.

JD 5510 engine breakdowns. Diesel motor starts hard regularly. How could i fix it?

Restricted Fuel Lines. Air leakage to the fuel inlet. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Clogged fuel filter. Clean or replace fuel filter. Long Idle periods.

Steering doesn’t function on our tractor. What repairs should I do?

The hydraulic system has air. You need remove air. Small level of oil in system. Pour completely. Steering hydraulic cylinder worn out Make a replacement.

I use the exact same tractor. Why diesel motor doesn't start? How could i fix this defect?

Valve timing is improper - Adjust valve timing. Low compression. Cylinder bores wear - You must fix it. Leakage between seats and valves - Remove leaks.

John Deere 5510 failures. I hear a diesel knock. what kind of problem?

Oil of small quantity. You should pour this. Cooling temperature is minimum.

I can't find the reason why driving front axle to howls incessantly when tractor run?

Defective gear. It is recommended to replace the gear. Roller bearings are firmly erased. Fit new bearings.

I have this model less than five years. Recently, engine start is intermittent. How to get rid of this?

Injector has dirt. Need to diagnose a nozzle. The fuel pump does not work. Requires replacement of injection pump.

I bought the same tractor. Tell me what's problem if differential lock assembly broke down immediately? What's solution to the problem?

Diaphragm worn out or discs friction clutch worn out. Requires repair.

We have 5510 tractor. Motor not working. I need to know can i fix the problem?

Possibly this is a clogged fuel filter. Or injection pump to lost adjustments.

Please help. Motor overheating occurs. What is the fault?

Coolant level lowered. Pour liquid into radiator to recommended level. Radiator screen or fins clogged - Clean radiator screen or fins. Engine overloaded - Reduce engine load. Fan belt is damaged. Change as required.

My father has John Deere 5510 with 553 loader. Yesterday he heard a noise in the rear axle. What is the malfunction?

These symptoms denote bearing problems.

Can someone say me what is problem if diesel exhaust white gas?

When white gas comes out of exhaust pipe you required to carry out replacement of piston rings immediately. Piston ring and cylinder worn or stuck - Repair or replace.

JOHN DEERE TRACTORS ATTACHMENTS
1023E	2025R	2210	2520	3032E
3046R	3520	4066R	4105	4200
4320	4400	4520	4600	4720
430	420	455	X300	X350
X485	X500	X590	X700	X738

JOHN DEERE TRACTORS TROUBLESHOOTING
2640	3040	3310	3650	4100
5050D	5090R	5410	6105R	7200R
E130	L111	LA110	LT155	X300R