________________________________________________________________________________

John Deere 7920 - Problems and Solutions

Yesterday I found out trouble on my John Deere 7920. Diesel doesn't crank. Tell me please what could be the malfunction?

You must use the recommended fuel grade. Broken drive on fuel injection pump. Check and repair. Wrong fuel injection pump timing. Adjust if necessary.

JD 7920 breakdowns. Low engine power. How do I fix an issue?

Burnt nozzle Have it repaired by the service representative. Engine’s moving parts seem to be seizing - Repair or replace.

Tell me please what is defect if engine stalling?

Water separator clogged - Clean water separator.

7920 tractor question. Transmission rough shifting. What's fault?

Front bearing retainer loose or cracked - Tighten or replace retainer.

Somebody help me why my steering wheel spinning too easy? How do I act to correct the situation?

Low hydraulic oil level in tank - It is required to add oil. Steering cylinder has a defect - Replace the defective part. Pump steering broke - Check the steering pump.

I acquired a John Deere 7920 in april. Presently there is trouble. Diesel won't start. Can anyone help me define the source of failure?

Starter rotates slowly - Change or refit. Dirt in the fuel system - You should make washing and cleaning. Fuel filter is dirty - Replace it. Piston ring failure - Install new piston rings.

I bought the same tractor. Yesterday I saw steering wheel operate tight. Tell me what is a breakdown?

Minimum Oil Rating. Insufficient oil delivery from the hydraulic pump. Check the hydraulic pump suction line and filter. Fix as required. Oil flows out of the system. It is necessary to eliminate a fault. Power steering pump defect. Repair the pump. Power steering is worn out. Install the new power steering.

JD 7920 tractor failure. Motor hard starting. Need help to determine the source of trouble. What can I do?

Low compression. Oil pump worn or passages obstructed. Cold start system worked incorrectly. Broken or Worn Piston Rings. Cracked injector Body or Cup. Water, dirt, or air in fuel system. Drain, flush, fill and bleed system. Crankcase oil too heavy. Use oil of proper viscosity.

John Deere 7920 diesel problems. Diesel long starting regularly. How could i fix damage?

Clogging in fuel tank vent. Air Leaks in Suction Lines. Exhaust pipe is clogged. Low voltage - Charge battery. Diesel injection nozzles faulty or sticking. Filter clogged. Fuel shut-off valve closed. Open fuel shut-off valve.

Steering does not operate on our tractor. Why did this happen?

The air is in hydraulic system. You should draw out air. Small level of oil in system. Pour completely. Steering hydraulic cylinder is damaged Repair it.

I have the exact same model. Why motor does not start? How do i fix it?

Valve timing is incorrect - Make adjustment. Low compression. Worn cylinder bores - Need overhaul. Leaks between seats and valves - Need Removal of leakage.

JD 7920 problems. Diesel knocks. what could be the damage?

Oil of small quantity. Fill with oil. This is the low temperature of the coolant.

I can not understand why tractor front axle to howls constantly while driving?

Defective gear. You must change the gears. ball bearings are very worn out. Swap the replacement.

I have this model three years. Often diesel start is intermittent. What a breakdown?

Injector has clog. It is required to diagnose injector. High-pressure fuel pump does not work. Repair high-pressure fuel pump.

I have the same tractor. Can anybody tell me what's problem if differential lock assembly does not work immediately? How can I fix it? What should I do?

Diaphragm worn out or replace friction clutch discs. Change worn components.

Our company has John Deere 7920. Engine does not start. I need to know what's issue?

Probably fuel filter clogged. Otherwise the fuel pump adjustment is not correct.

I have the problem. Motor overheats regularly. What kind of malfunction?

Little coolant in the cooling system. You need to fill the system. Choked radiator fins - Clean it. Insufficient coolant - Top up coolant. Choking of cooling system - Clean the cooling system. Engine overloaded - Reduce engine load. Broken or misadjusted fan belt - Adjust or replace.

My friend has 7920 tractor. Today he got a crunch in the crankcase of the drive axle. What's wrong?

All signs evidence of defect in the axle reducer.

Tell me what is defect if diesel exhaust white gas?

When white gas appeared from the exhaust pipe you must to replace piston rings urgently. Oil level too high - Reduce to correct quantity.

JOHN DEERE TRACTORS ATTACHMENTS
1023E	2025R	2210	2520	3032E
3046R	3520	4066R	4105	4200
4320	4400	4520	4600	4720
430	420	455	X300	X350
X485	X500	X590	X700	X738

JOHN DEERE TRACTORS TROUBLESHOOTING
2640	3040	3310	3650	4100
5050D	5090R	5410	6105R	7200R
E130	L111	LA110	LT155	X300R